Published by WS 0665 BG CD Customer Service Printed in the Netherlands Subject to modification EN 3122 785 16430©Copyright 2006 Philips Consumer Elect
Service Modes, Error Codes, and Fault FindingEN 10 L04.6HU CA5.5. Service Modes, Error Codes, and Fault FindingIndex of this chapter:5.1 Test Points5
Service Modes, Error Codes, and Fault FindingEN 11L04.6HU CA 5.5. Option bytesShows the actual settings of the options; seven codes possible.6. Clear
Service Modes, Error Codes, and Fault FindingEN 12 L04.6HU CA5.the Force/SearchMan electronic manual of the defective chassis, schematics and PWBs are
Service Modes, Error Codes, and Fault FindingEN 13L04.6HU CA 5.Table 5-1 Error code overviewNote: For all error codes the following applies: error cod
Service Modes, Error Codes, and Fault FindingEN 14 L04.6HU CA5.5.7.2 ATSC ModuleATSC Module checkFigure 5-4 Fault finding tree “ATSC Module check” 5.7
Service Modes, Error Codes, and Fault FindingEN 15L04.6HU CA 5.5.7.4 DeflectionOne Thin Vertical LineQuick check:• Set in protection mode.• LED blinki
Service Modes, Error Codes, and Fault FindingEN 16 L04.6HU CA5.6. If Tuner IF is present and yet still no picture in RF mode, go to Video Processing t
Service Modes, Error Codes, and Fault FindingEN 17L04.6HU CA 5.5.7.7 ControllerBelow are some guidelines for troubleshooting of the Micro Controller f
Service Modes, Error Codes, and Fault FindingEN 18 L04.6HU CA5.
Block Diagrams, Test Point Overviews, and Waveforms 19L04.6HU CA 6.6. Block Diagrams, Test Point Overviews, and WaveformsWiring DiagramG_16430_012.eps
Technical Specifications, Connections, and Chassis OverviewEN 2 L04.6HU CA1.1. Technical Specifications, Connections, and Chassis OverviewIndex of thi
20L04.6HU CA 6.Block Diagrams, Test Point Overviews, and WaveformsBlock Diagram Supply and DeflectionPOWER SUPPLY150442398417181314563213507F_15760_0
Block Diagrams, Test Point Overviews, and Waveforms 21L04.6HU CA 6.Testpoint Overview Mono CarrierF_15760_043.eps1511053139 123 5673.4SERVICE TESTPOIN
22L04.6HU CA 6.Block Diagrams, Test Point Overviews, and WaveformsBlock Diagram VideoF201 2V / div DCF203 2V / div DC500mV / div DC10ms / div1V
Block Diagrams, Test Point Overviews, and Waveforms 23L04.6HU CA 6.Testpoint Overview CRT PanelF_15760_039.eps1511053139 123 5674.3SERVICE TEST POINT
24L04.6HU CA 6.Block Diagrams, Test Point Overviews, and WaveformsBlock Diagram Audio/ControlG_16430_014.eps260406HERCULESA4A3REAR I/O CINCHA8A5SP/LS
Block Diagrams, Test Point Overviews, and Waveforms 25L04.6HU CA 6.I2C and Supply Voltage OverviewPOWER SUPPLY432984171814135321G_16430_015.eps2604063
26L04.6HU CA 7.Circuit Diagrams and PWB Layouts7. Circuit Diagrams and PWB LayoutsMono Carrier: Power Supply+t-T+tRsRpVVALLEYSUPPLYPWMPOWER-UPRESETTH
Circuit Diagrams and PWB Layouts 27L04.6HU CA 7.Mono Carrier: Diversity Table for [A1]2537254425452570353235333535353635383539354255315532130V 143V 13
28L04.6HU CA 7.Circuit Diagrams and PWB LayoutsMono Carrier: DeflectionFOCUSVG2EHT126V970V60VTO PICTURE TUBE110V27V61401 B31402 A41404 C61451 F101452
Circuit Diagrams and PWB Layouts 29L04.6HU CA 7.Mono Carrier: Diversity Table for [A2]249047n-----47n- ----47n--- - - ---- - --640464116412DVM1500M---
Technical Specifications, Connections, and Chassis OverviewEN 3L04.6HU CA 1.Rd - Audio R 0.5 VRMS / 10 kohm jqAV2 - Cinch: Video CVBS - In, Audio -
30L04.6HU CA 7.Circuit Diagrams and PWB LayoutsMono Carrier: Tuner IFNCMTGND13(For Lightning Protection)IRESA4***B10*HTO 0282I016 A6I017 D45V6101211A
Circuit Diagrams and PWB Layouts 31L04.6HU CA 7.Mono Carrier: HerculesAUDOUTSRAUDOUTSLAUDOUTLSRAUDOUTLSLAUDOUTHPRAUDOUTHPLAGCOUTGND1GND2GND3GNDAVSSA1V
32L04.6HU CA 7.Circuit Diagrams and PWB LayoutsMono Carrier: Features & ConnectivityCOMOUTIN1A4A4AV PANELTo 1252 of CRT PANELA4OFA46V3V3A4A4PCF85
Circuit Diagrams and PWB Layouts 33L04.6HU CA 7.Mono Carrier: Class D - Audio AmplifierDIAGVSS2POWERUPEN2REL2VDD1SW2VDD2VSS1BOOT2OUT2SW1EN1STABBOOT1RE
34L04.6HU CA 7.Circuit Diagrams and PWB LayoutsMono Carrier: Audio Amplifier*6992 E47990 A67991 C57992 C47993 D48 ohm / 15WA4A4+16V+16V8 ohm / 15WTO
Circuit Diagrams and PWB Layouts 35L04.6HU CA 7.Mono Carrier: Rear I/O Cinch*D2FRESI111 E6I112 F6I113 D8I114 E8I115 C8I116 D7I117 F8I118 F9YBC45I107 C
36L04.6HU CA 7.Circuit Diagrams and PWB LayoutsMono Carrier: Front ControlA4FRONT CONTROLA9A9F_15760_019.eps1611053139 123 5673.4for ITV onlyA4F695 D
Circuit Diagrams and PWB Layouts 37L04.6HU CA 7.Mono Carrier: DVD PSU (optional)COMOUTINVCCOSCSS_INHCOMP GND BOOTOUTFB7A2583 B22584 B32585 C32586 B425
38L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout Mono Carrier: (Top Side)F_15760_021.eps1511053139 123 5673.41000 E71001 E51002 E51003 E51004 E7
Circuit Diagrams and PWB Layouts 39L04.6HU CA 7.Layout Mono Carrier (Overview Bottom Side)F_15760_022.eps1511053139 123 5673.4Part 1F_15769_022a.epsPa
Safety Instructions, Warnings, and NotesEN 4 L04.6HU CA2.2. Safety Instructions, Warnings, and NotesIndex of this chapter:2.1 Safety Instructions2.2
40L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout Mono Carrier (Part 1 Bottom Side)Part 1F_15760_022a.eps151105
Circuit Diagrams and PWB Layouts 41L04.6HU CA 7.Layout Mono Carrier (Part 2 Bottom Side)F_15760_022b.eps151105Part 2
42L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout Mono Carrier (Part 3 Bottom Side)F_15760_022c.eps151105Part 3
Circuit Diagrams and PWB Layouts 43L04.6HU CA 7.Layout Mono Carrier (Part 4 Bottom Side)F_15760_022d.eps151105Part 4
44L04.6HU CA 7.Circuit Diagrams and PWB LayoutsATSC Panel: Power5544332211D DC CB BA APOWERPower and Ground Test Points10VDC5VDC5VDC10VDC5VDC2V5DC1V8
Circuit Diagrams and PWB Layouts 45L04.6HU CA 7.ATSC Panel: Reset, Pads, Spade Lug, I2C EEPROM5544332211D DC CB BA AGrounded Mounting Holes, PCBReset
46L04.6HU CA 7.Circuit Diagrams and PWB LayoutsATSC Panel: DDR SDRAM Interface5544332211D DC CB BA ADDR SDRAM INTERFACEDDR Bypass Cap sVREF Generatio
Circuit Diagrams and PWB Layouts 47L04.6HU CA 7.ATSC Panel: Guest Bus & Flash5544332211D DC CB BA Apin37GUEST BUS & FLASHpin13pin47FLASH MEMOR
48L04.6HU CA 7.Circuit Diagrams and PWB LayoutsATSC Panel: Tuner5544332211D DC CB BA ATUNER & OREN CASCADE DEMODULATORI2C Addre s: C2TS ERRORLOCK
Circuit Diagrams and PWB Layouts 49L04.6HU CA 7.ATSC Panel: Connectors5544332211D DC CB BA AJTAG/EJ TAGCONNECTORS* Key Pin 12DON`T STUFF R721,R719,R72
Safety Instructions, Warnings, and NotesEN 5L04.6HU CA 2.• Where necessary, measure the waveforms and voltages with (D) and without (E) aerial signal.
50L04.6HU CA 7.Circuit Diagrams and PWB LayoutsATSC Panel: Video Out5544332211D DC CB BA ADAC GainVIDEO OUTZR39640BGCCDon`t stuffDon`t stuffDon`t stu
Circuit Diagrams and PWB Layouts 51L04.6HU CA 7.ATSC Panel: Audio Output5544332211D DC CB BA A(DDX Audio Out Right)(DDX Audio Out Left)AUDIO OUTPUTdon
52L04.6HU CA 7.Circuit Diagrams and PWB LayoutsATSC Panel: Power & Gnd5544332211D DC CB BA APOWER AND GROUND (ATV & DDR)ZR39640BGCCPLL_VDDADA
Circuit Diagrams and PWB Layouts 53L04.6HU CA 7.ATSC Panel: YUV Converter5544332211D DC CB BA AYUV CONVERTERDON`T STUFFDON`T STUFFDON`T STUFFVIDEO OUT
54L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout ATSC Panel (Top Side)G_16430_024.eps1005063139 267 2819.1Layout ATSC Panel (Bottom Side)G_16430
Circuit Diagrams and PWB Layouts 55L04.6HU CA 7.CRT PanelBlueGreenRed3k75188k73k773k75188k73k773k75188k7Vref7VPROTECTIONTHERMALBC1A1VrefVdd2.5V3k77A2V
56L04.6HU CA 7.Circuit Diagrams and PWB LayoutsCRT Panel: Eco ScavemROTATION COILTO17V78V79V48V7I362 B3I363 C4I364 C3I365 B5I366 A5I367 A5I368 A6I369
Circuit Diagrams and PWB Layouts 57L04.6HU CA 7.Layout CRT Panel (Top Side)Layout CRT Panel (Bottom Side)F_15760_025.eps1511053139 123 5674.30316 A203
58L04.6HU CA 7.Circuit Diagrams and PWB LayoutsSide AV + Headphone PanelCI155 C4I169 C9I170 B117SPEAKER**TOTOECO SUBI171 C11SG01 B4SG02 C4SG03 E42181
Circuit Diagrams and PWB Layouts 59L04.6HU CA 7.Layout Side AV + Headphone Panel (Top Side)Layout Side AV + Headphone Panel (Bottom Side)F_15760_028.e
Directions for UseEN 6 L04.6HU CA3.3. Directions for UseYou can download this information from the following websites:http://www.philips.com/supportht
60L04.6HU CA 7.Circuit Diagrams and PWB LayoutsExternal SupplyEPS1BE_14820_028.eps150904EXTERNAL SUPPLYZD1100kC38220pFD1UF4005GC447pC20100nC21100nC64
Circuit Diagrams and PWB Layouts 61L04.6HU CA 7.SP/LS Module (NA-LA)3139 188 61511_ SP/LS( EU ) Module3139 188 61501_SP/LS( NA-LA ) Module3139 267 193
62L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout SP/LS Module (NA-LA) (Top Side)G_16430_020.eps0505063139 123 6155.1Layout SP/LS Module (NA-LA)
Circuit Diagrams and PWB Layouts 63L04.6HU CA 7.Interface Module123450228EH-B(5)+5V3740220R6703BZX79-C5V1+2703100u+5V6709 PRLL581737252K237386K8372410
64L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout Interface Module (Top Side)G_16430_022.eps0505063139 123 6164.1Layout Interface Module (Bottom
Circuit Diagrams and PWB Layouts 65L04.6HU CA 7.Main Switch Panel (For SL5 Styling)6789ABCD1031 A81004 C61005 D6**I031 B6POWERMAINS*****RES*123EAB455V
66L04.6HU CA 7.Circuit Diagrams and PWB LayoutsLayout Main Switch Panel (For SL5 Styling) (Top Side)F_15760_031.eps1611053139 123 6015.30201 A20202 A
AlignmentsEN 67L04.6HU CA 8.8. AlignmentsIndex of this chapter:8.1 General Alignment Conditions8.2 Hardware Alignments8.3 Software Alignments and S
AlignmentsEN 68 L04.6HU CA8.8.3 Software Alignments and SettingsFigure 8-3 Service Mode overview (Analog TV mode)
AlignmentsEN 69L04.6HU CA 8.Enter the Service Alignment Mode (see also chapter 5 “Service Modes, ...”). The SAM menu will now appear on the screen. S
Mechanical InstructionsEN 7L04.6HU CA 4.4. Mechanical InstructionsIndex of this chapter:4.1 Set Disassembly4.2 Service Position4.3 Assy/Panel Remov
AlignmentsEN 70 L04.6HU CA8.Option Bit AssignmentTable 8-2 Option code overview per model Byte Bit Option Model27HT4000D/27 27HT7210D/27Byte_0 (TV Sy
AlignmentsEN 71L04.6HU CA 8.Byte_5 (Feature) 7ITV Ring 0 06Protection 1 15WatchDog 1 14 No Ident Standby 1 13 Buzzer Type 0 02 None=00, Internal=01,
AlignmentsEN 72 L04.6HU CA8.8.3.2 TunerNote: Described alignments are only necessary when the NVM (item 7601) is replaced.IF PLLThis adjustment is aut
AlignmentsEN 73L04.6HU CA 8.Horizontal• Horizontal Parallelogram (HP). Align straight vertical lines in the top and the bottom; vertical rotation arou
Circuit Descriptions, List of Abbreviations, and IC Data SheetsEN 74 L04.6HU CA9.9. Circuit Descriptions, List of Abbreviations, and IC Data SheetsInd
Circuit Descriptions, List of Abbreviations, and IC Data SheetsEN 75L04.6HU CA 9.the settings for favorite stations, customer-preferred settings, and
Circuit Descriptions, List of Abbreviations, and IC Data SheetsEN 76 L04.6HU CA9.9.3 Supply Architecture9.3.1 Block Diagram Figure 9-3 Block diagram P
Circuit Descriptions, List of Abbreviations, and IC Data SheetsEN 77L04.6HU CA 9.B (Hercules Port)This port is used to switch “on” the +12V of the ATS
Circuit Descriptions, List of Abbreviations, and IC Data SheetsEN 78 L04.6HU CA9.IIC Integrated IC busITV Institutional TV LATAM Latin American countr
Spare Parts ListEN 79L04.6HU CA 10.10. Spare Parts ListNot available at the time of publishing
Mechanical InstructionsEN 8 L04.6HU CA4.4.3.3 ATSC Module/Panel RemovalFigure 4-4 ATSC bracket1. Disconnect all cables that lead to the module.2. Unlo
Revision ListEN 80 L04.6HU CA11.11. Revision ListManual xxxx xxx xxxx.0• First release.
Mechanical InstructionsEN 9L04.6HU CA 4.4.3.6 SP/LS Module/Panel RemovalFigure 4-8 SP/LS Module1. Loosen the screw [1] that fixes the bracket with the
Comments to this Manuals